2006 Ford Fusion Air Bags Problems
- 301
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 301 stored complaint records:
- 18 indicate a crash
- 12 indicate injury
- 0 indicate fire
What owners report
- takata recall · 81 records
- parts recall · 25 records
- failure parts · 16 records
- recall remedy · 16 records
- part recall · 14 records
- parts distribution · 12 records
Mileage in stored records
| Band | Records |
|---|---|
| 100–150k mi | 23 |
| 60–100k mi | 14 |
| 150–400k mi | 11 |
| 30–60k mi | 9 |
| 1–30k mi | 7 |
Complaint records
Owner-submitted complaint content, presented as stored.
Air Bags
Takata recall notified over a year ago that my car was under this recall. Notified again july 2016 that i would be receiving a letter when my air bag became available and to notify my dealer. Called dealer and he said probably by dec. 2016. Now the dealer is telling me april 2017. This is totally unacceptable since my two granddaughters drive this car to college four days a week. Your prompt attention to this matter…
ODI 10944469
Air Bags · Service Brakes
Tl* the contact owns a 2006 ford fusion. The contact stated that while driving at approximately 45 mph attempting to engage the brakes, the brakes failed to stop the vehicle causing it to crash into the rear of another vehicle. The airbags failed to deploy and the seat belt did not lock. The contact sustained unknown injuries and medical attention was required. A police report was filed. The vehicle was not…
Crash reported · 1 injury
ODI 10672530
Air Bags · Unknown Or Other · Vehicle Speed Control
Airbags did not deploy during car accident. Airbags recalled by takata are far more dangerous, basically dead airbags. The vehicle was in motion, another recall with the carpets being recalled as well, resulting in excessive speed from the carpet pressing on the gas peddle, causing the accident.
Crash reported · 1 injury
ODI 11150194
Air Bags · Structure
The dashboard is bulging/buckling against the passenger side airbag. The bubble appears to be caused by the dash material surrounding the airbag becoming detached or unglued. The position of this bulging and separation cause concern that the airbag may malfunction upon deployment. *tr
ODI 10626640
Air Bags · Structure
Tl* the contact owns a 2006 ford fusion. The contact stated that the passenger side dashboard was separating which could possibly expose the air bag. The contact mentioned that the passenger side air bag light illuminated. The vehicle was taken to a dealer where it was diagnosed that the entire dashboard needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure…
ODI 10626159
Air Bags · Structure
Tl* the contact owns a 2006 ford fusion. The contact noticed a protrusion on the passenger side dashboard where the air bag was located. It appeared as if the air bag would deploy at any moment. The vehicle was taken to two mechanics who both stated that the protrusion was not caused by the air bag. The vehicle was taken to a body shop and the mechanic stretched the material to repair the dashboard and closed the…
ODI 10619215
Air Bags · Engine
When driving on the highway and roadway, such as bridges this summer, my vehicle stalled several times, lost power coming almost to a complete stop, putting my family and i at risk. When i pressed on the gas to accelerate, the engine begin to race, causing the "check engine light" to come on. It also jerked and skidded as i tried to maneuver the steering. To avoid accidents on these occasions, the vehicle had to be…
ODI 10659476
Air Bags · Structure
The dashboard is separating from the passenger air bag area and seems to be stretched by something, unsure as to cause as nothing is apparent. Also the front left defroster air vent near the windshield started to detach from the dashboard as if it was under spring pressure to do so. The local dealer says there is no fix for this to his knowledge , except to replace the entire dashboard. The dashboard does not appear…
ODI 10622183
Air Bags
Tl* the contact owns a 2006 ford fusion. The contact stated that while sitting idle, the front passenger side air bag erroneously deployed. The contact was startled, as there was no impact to the vehicle to warrant air bag deployment. The dealer was made aware of the failure and declined to assist. The manufacturer was also made aware of the failure but provided no assistance due to the age of the vehicle. The…
ODI 10575409
Air Bags
Tl* takata recall. The contact owns a 2006 ford fusion. The contact stated that the air bag indicator remained illuminated. Jim hudson ford (1201 w main st, lexington, sc 29072, [redacted]) was contacted, but the part was not available for nhtsa campaign number: 16v384000 (air bags). The vehicle was not repaired and was traded-in for a 2014 ford fusion. The manufacturer was notified. The failure mileage was not…
ODI 11171723
Air Bags
Tl* the contact owns a 2006 ford fusion. The contact stated that while traveling 45 mph, the vehicle was involved in a crash with another vehicle. Upon impact, the air bags did not deploy, which caused the contact's chest to strike the steering wheel. The contact sustained back, neck, hip and chest injuries. The vehicle was destroyed. The manufacturer had not been contacted. The failure and current mileages were…
Crash reported · 1 injury
ODI 10476846
Air Bags
I was sent a letter about the passenger airbag needing replaced. I had this done september 2012 because the warning light was on. Do i get a refund since i already had to take care of it.
ODI 10897429
Air Bags · Equipment Adaptive/Mobility
Passenger side air bag bulging out of the console afraid it is going to discharge at anytime and hurt myself or passenger this is dangerous. Also front driver side lock decided to break and only way to exit is to roll down window also has potential to be dangerous. Why is there not a recall on all these dangerous items that seem to reappear on every complaints listed. *tr
ODI 10658865
Air Bags · Suspension · Underbody Shields
2006 ford fusion: two safety issues 1. The dashboard on the passenger side near the air bag is warped/bulged. The air bag indicator flashes on every once in awhile. I am concerned the air bag will deploy causing harm. This is a major safety concern. 2. Complaint: cracking and popping in my front suspension when turning or going over bumps. About two years ago i took my car to a ford dealership and they stated there…
ODI 10555053
Air Bags · Service Brakes, Hydraulic
Exiting the freeway at 40mph the brakes failed and my wife hit the barriers and the air bags never deployed. *tr
Crash reported
ODI 10254185
Air Bags
I bought this car new in 2006 and still have been told that i'll have to wait for new air bag recall to be installed
ODI 11143025
Air Bags · Side/Window
I was proceeding through an intersection to turn left. A car that was supposed to stop ran the red light and t-boned me directly in the driver's side. His airbag deployed (front). My 2006 ford fusion is equipped with front and side airbags. None of them deployed. I was transported to the hospital with fractured ribs and ultimately, needed pt to restore my neck and left arm rotator cuff to full use and back to normal…
Crash reported · 1 injury
ODI 10285610
Air Bags
Takata recall - see attached letter - still no parts available for a "high risk" vehicle. The delay in addressing this serious and dangerous problem is ridiculous.
ODI 11141040
Air Bags · Unknown Or Other
TAKATA RECALLED AIRBAG
ODI 11143066
Air Bags
I almost killed in a near fatal collision on january 15, 2007. I was in a 2006 ford fusion sel with front and side airbags. My car was demolished and but for the grace of god i survived despite my failed airbags. I informed ford as you can see they started to deploy and stick out a little. The photos prove they failed. Ford is making it difficult to follow through and i have the car being held so it can be…
Crash reported · 1 injury
ODI 10184744
Air Bags
This vehicle has an air bag safety recall and the passenger air bag light is on. I can't have a passenger ride in my car due to this danger recall 16s26/nhtsa recall 16v-384and this vehicle is 12 years old and parts are still not available. What good is a vehicle that can't have a passenger due to a danger recall!! I must have this repaired, this car should be considered a lemon law!!! Please advise what my next…
ODI 11141827
Air Bags
Dt*: the contact stated the vehicle was in an accident at 55 mph into a sand dune. The car rolled over four times and the air bags did not deploy. There was no air bag warning light illuminated prior to or after the incident. The vehicle was deemed a total loss by the insurance company and has not been taken to a service dealer.*ak
Crash reported
ODI 10172785
Air Bags
Have recently iced numerous recall notices and all i get from the dealer is they don't have any replacement parts. Couldn't find any information about complaining except at this site. Last information i got was they will have parts in oct on now it's nov.
ODI 11149530
Air Bags
Takata recall dealer cannot repair. Dealer has failed to complete repair.
ODI 11150924
Air Bags
Takata recall. My passenger side front airbag has still not been fixed and parts are still not available. It is unacceptable this has gone on so long and the dealership still does not have replacement parts.
ODI 11051159