FordFusion2006
  1. Ford Fusion
  2. Problems
  3. 2006
  4. Suspension

2006 Ford Fusion Suspension Problems

7
Owner complaint records in our dataset

Records are owner complaints, not a measured failure rate.

Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.

Mileage in stored records

BandRecords
30–60k mi2
60–100k mi2

Complaint records

Owner-submitted complaint content, presented as stored.

  • January 1, 2019

    Suspension

    Rear suspension completely rusted out not repairable needs replacement at 40,000 miles,2006 ford fusion

    ODI 11176130

  • August 5, 2017

    Steering · Suspension · Wheels

    AXLE /DRIVE SHAFT BROKE WHILE IN MOTION

    ODI 11013731

  • September 11, 2012 · 89,000 miles

    Power Train · Suspension

    I have a 2006 fusion this problem started a year ago. First my car shakes, when driven 20mph and try to accelerate it has a hard time picking up speed it misses. So i had my spark plugs changed twice in the last year because i thought that's what was wrong. I took it to my local good year and they noticed that i've had my spark plugs changed with them twice so, the mechanic took my car apart and found that my 5th…

    ODI 10538268

  • February 28, 2012

    Equipment · Suspension · Underbody Shields

    06 ford fusion. I have been having a cracking sound in the front right suspension, took it in to ford to get tires done, they found that my front subframe welds have cracked and it would cost 1500 to fix with a used part, the complaint is , when i came home and researched this issue, i have found tons and tons of complaint with this same issue, it appears to be a failure of ford to have a correct weld placed in this…

    ODI 10449734

  • February 1, 2012 · 82,000 miles

    Suspension

    Tl* the contact owns a 2006 ford fusion. The contact stated that while driving at various speeds and going over bumps, a loud noise was heard in the front end. The vehicle was taken to an independent mechanic. After diagnosis, they advised him that the welds were fractured and needed to be replaced. The vehicle was not repaired. The manufacturer was later contacted. The failure mileage was approximately 82,000. The…

    ODI 10500020

  • August 1, 2010 · 50,000 miles

    Air Bags · Suspension · Underbody Shields

    2006 ford fusion: two safety issues 1. The dashboard on the passenger side near the air bag is warped/bulged. The air bag indicator flashes on every once in awhile. I am concerned the air bag will deploy causing harm. This is a major safety concern. 2. Complaint: cracking and popping in my front suspension when turning or going over bumps. About two years ago i took my car to a ford dealership and they stated there…

    ODI 10555053

  • November 12, 2007 · 33,725 miles

    Suspension

    The vehicle has a noise that is similar to a strut that is lose, that started out as slight noise and has subsequently gotten louder. The fusion has a v-6 and is now out of warranty and was purchased new; the problem has existed for years with no dealer having a solution to the problem. That noise has been investigated by two separate ford dealers, (one where we purchased the vehicle) the other an independent ford…

    ODI 10405281