2015 Ford Fusion Fuel/Propulsion System Problems
- 30
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- engine light · 5 records
- check engine · 5 records
- same issue · 4 records
Mileage in stored records
| Band | Records |
|---|---|
| 30–60k mi | 9 |
| 60–100k mi | 8 |
| 1–30k mi | 7 |
| 100–150k mi | 3 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel/Propulsion System
42k. Engine light came on, diagnostics reported a bad 02 sensor. Never had any kind of issues with an 02 sensor. Can't believe it happened on a 2015 model.
ODI 11271203
Engine · Fuel/Propulsion System
Started car, got dashboard light on 7.6.19 mileage 27721. Car running rough, about to stall,etc. Error code p0302. Cyl.#2 ignition coil replaced. Then, 2 weeks later got dashboard light again, same code p0302. Mechanic (private)replaced perceived faulty ignition coil as previous. On 9.23 .19 car started,. Car runs rough, almost stalls dashboard lights again. This time we take it to royal oak ford service dept. They…
ODI 11258356
Engine · Fuel/Propulsion System
Tl* the contact owns a 2015 ford fusion. The contact stated that the vehicle stalled while driving and would not restart. The vehicle was taken to felix sabates ford lincoln ([redacted], charlotte, nc 28273) where it was determined not to be included in nhtsa campaign number: 18v735000 (fuel system). The manufacturer was made aware of the failure. The vehicle was diagnosed or repaired. The failure mileage was…
ODI 11202978
Fuel/Propulsion System
Every time i fill up the gas tank and i attempt to start the car, the car runs rough and stalls. It takes two or three time of trying to start the car before it will start. It will run rough for a while be it starts running normal.
ODI 11187382
Engine · Fuel/Propulsion System
After refueling the vehicle is difficult to start, pumping the accelerator helps but the engine will stall suddenly within a few miles of the fill up. On two occasions i have lost power when driving on a major street with 1/4-1/2 tank of fuel. This stall is preceeded by a loud, disonate noise from the fuel filler. There is www information regarding failed purge valves, but most information is for earlier models. The…
ODI 11172164
Fuel/Propulsion System
My vehicle stalls after fueling and also while driving. It seems to be a problem with many ford fusions. While driving, the cap less gas filler will start vibrating and relieving pressure from the fuel system. This is causing the car to act like it is misfiring and run rough. Before i have time to pull off the busy city street the car will shut off and i'm left sitting in the middle of the road trying to get the car…
ODI 11172036
Fuel/Propulsion System
Car would intermittently stall at low speeds and would shake and shutter until the engine quit. This would take place after warm up and the car had been driven for several miles. Car would restart after hard cranking after moving gear shift into park. This would take place at stop lights, in the driveway and on the street while in traffic. Dealer replaced throttle body (part # ds7z 9e926c) after verifying code from…
ODI 11171706
Fuel/Propulsion System
CAR STALLS WHEN STARTING OUT
ODI 11170312
Engine · Fuel/Propulsion System
Filled up car w/ gas, car sputtered like it was not getting gas. Car shut off but power stayed on. Tried to start car again, & it sputtered again. I then pushed on accelerator to give gas, and car sputtered as i let off, then died, but still had power. Started car for 3rd time, and it continued to sputter, i pushed on accelerator, and put in drive, and as i drove about 20 meters, the car seemed to still sputter.…
ODI 11160628
Engine · Fuel/Propulsion System
Awhile back the car started making strange noises, that came from the fuel inlet behind the gas door, sounding like pressure escaping. Pressing the door in (capless fuel tank) confirms this, as the vacuum is released. Car idles rough, and in some cases, after refueling, it will immediately stall. Upon further research, it seems to happen to quite a few fusion owners, with videos and forums posts to verify. Ford…
ODI 11142746
Fuel/Propulsion System
Check engine light code indicates catalytic converter failure. Oil changed according to manufacturers recommendations. Car is driven less than 100 miles per month. Indicator light comes on and goes out intermittently. Car is only 3 years old.
ODI 11143547
Fuel/Propulsion System
My car since i bought it has had the same issue of turning off either while driving or right after i get gas and not starting back up. I have gotten the purge valve replaced as that is what the dealer said was the issue and one year later i'm having the same issue. It seems this is a huge problem for fords since they recalled over a million ford focus vehicles for the same issue but my model is not on the recall…
ODI 11300060
Fuel/Propulsion System · Unknown Or Other
My vehicle makes a noise while driving and this noise comes from the gas tank. It is like a honk sound. To stop the sound, i have to stop the vehicle, open the gas tank and let the air/pressure inside the gas thank out. The smell is some kind of burnt engine or wire. After i have let the air/pressure out, engine warning light turns on for few hours and goes off. There are lots of customers with this same issue and…
ODI 11131061
Engine · Fuel/Propulsion System · Vehicle Speed Control
While driving this vehicle the engine misfires decrease in power and completely stops acceleration. It also uses a great deal of fuel. The coolant constantly leaks out and the engine overheats every few minutes. The car also overheats when sitting in a parked position. While driving on the freeway the car slowed to 25mph. We were very close to being involved in an accident.
ODI 11119338
Fuel/Propulsion System
Initial failure of defective throttle bodies on ford escape and fusion,you have let ford get away with extending the warrenty on several years of this dangerous failure but they refuse to do anything when it fails and starts working again after sitting and restarting. While driving on a busy city street with multiple lanes it lost almost all power and they car slowed and would not accelerate. This can strand people…
ODI 11110603
Engine · Fuel/Propulsion System
Engine unexpectedly shuts off while driving. While driving at low speed in parking lot i went over a bump and then the engine shut off. Odometer is at approximately 44000. This occurred once before several months ago under the same conditions but i was not sure what to make of it.
ODI 11098394
Engine · Fuel/Propulsion System
This car has been in multiple times for loss of power and engine cutting out during acceleration. It has become dangerous. This is the ecoboost engine. Ford is not telling all about the dangers of this problem. I have almost been killed several times trying to accelerate into the roadway.
ODI 11142457
Fuel/Propulsion System
My check engine light came on about 3 weeks ago. After i fill up my tank the car won't start. I have to give it a lot of gas as i'm starting it for it to start. Within the past week it would not idle smoothly if i was at a stop sign or stop light. I've noticed this happens when i have around 1/4 tank of gas. Again, i've started putting my foot on the gas while i'm stopped to keep the idle smooth. I was able to get…
ODI 11083335
Engine · Fuel/Propulsion System
Engine stalls after fueling vehicle. Strong fuel odor after fueling vehicle
ODI 11076638
Fuel/Propulsion System
Takata recall i currently own a 2015 ford fusion se 2.0l turbo as the mileage has increased i have become aware of a problem with the purge vale, as i have having troubling starting my car after i put gas in it along with stalling. After some research i came upon articles of complaints about the same model car with the same purge valve problem. I believe this is a defect in the car that has dangerous safety hazards
ODI 11161865
Engine · Fuel/Propulsion System
In october 2017 my fusion stalled out four times (three various days and one day 15 minutes between stalls) and again on november 4th. Each time i was driving less than 10 mph; four times on a city street and once in a parking lot. In each case i had been driving for an hour or more and then stopped and turned off the car for a period of time (1/2 hour or so). When i got into the car to drive away the car would…
ODI 11043454
Engine · Fuel/Propulsion System · Unknown Or Other
While driving, my vehicle overheated. Checked coolant level, and it was less than half full. I refilled coolant to recommended level, and proceeded to drive. Two weeks later, it overheated again, and my coolant was low again. Refilled and monitored for leaks. No leaks. Then vehicle began misfiring. Diagnosed with cylinder 3 misfire. Replaced spark plugs and coil packs. Still misfiring. Rediagnosed with cylinder 3…
ODI 10985638
Engine · Fuel/Propulsion System
Car stalls after starting. When pulling away from a parked position car will hesitate shudder and accelerator will not work. Engine light comes on. After sitting several minutes the car will restart and run normally until the next time the car is parked and shut off.
ODI 10955034
Engine · Fuel/Propulsion System
Tl* the contact owns a 2015 ford fusion. While driving various speeds, the vehicle stalled and the check engine warning indicator illuminated. The contact powered off the engine while in traffic. The vehicle was restarted, but the failure recurred numerous times. In addition, the contact heard a loud abnormal noise coming from the fuel tank area while driving. The vehicle was not taken to a dealer or an independent…
ODI 11102441
Engine · Fuel/Propulsion System · Power Train
The 2015 fusion had a surge and the car jerked forward. My wife said that happened to her before. When it happened when i was in the car driving it we both looked at each other. This happened to us with the 2010 rav4 and the 2009 sienne that crashed into a tree. Please check this car for a computer problem.
ODI 10926644