2010 Ford Fusion Structure Problems
- 8
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Mileage in stored records
| Band | Records |
|---|---|
| 1–30k mi | 4 |
| 30–60k mi | 1 |
| 60–100k mi | 1 |
| 100–150k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Structure
Driver's side door cannot be opened from the inside. In the event of an emergency i cannot open the drivers side door unless i roll down the window and open from the outside of the vehicle. *tr
ODI 10713358
Structure
Tl* the contact owns a 2010 ford fusion. The contact stated that while at a traffic light and releasing the brake pedal, the vehicle accelerated independently to 60 mph. The contact lost control of the vehicle. The vehicle was taken to the dealer where it was diagnosed that the front driver side floor mat interfered with the accelerator pedal and needed to be replaced. The vehicle was repaired however, the failure…
ODI 10679229
Structure
Interior driver side door handle broke when attempting to open. Normal pressure was being applied to handle when the break occurred. Able to open door from exterior handle if window can be rolled down. This causes great concern if there is an emergency and unable to exit vehicle. Part is made of a low grade brittle plastic, replacement parts are of the same brittle plastic material. Same part as used on the 2006…
ODI 10632347
Structure
I opened the storage console that sits on the dash and the lid broke off the hinges. Parts are made of that hard plastic the heat and sun bakes till brittle. *tr
ODI 10461682
Instrument Cluster/Panel · Structure
Tl*the contact owns a 2010 ford fusion. The contact was unable to read the speedometer due to the reflection of the sunlight glare through the tinted windows in the vehicle. The vehicle was taken to an authorized dealer for inspection. The technician stated the problem experienced was a manufacturer design. The manufacturer was notified and there was concern of the safety risk involved. The failure mileage was 300.…
ODI 10299884
Structure
Safety issue. Design/engineering defect. 2010 fusion hybrid. Foot space between the knee airbag housing and brake pedal is severely and dangerously restricted by the physical presence, bulk, and location of the knee airbag. This delays response for instant brake deployment for emergency deceleration. Vertical clearance is ~4" and is less if approached at an angle, swiveling on heel from accelerator to brake. Lifting…
ODI 10334123
Electrical System · Structure
Our 2010 ford fusion is starting to split to split at the seams literally. On the passenger front door on the armrest where the window switch is, the panel is starting to separate & come apart. The top of the panel bulges upwards as if something in the door is pushing it up. My concern is especially here in nj with the recent snow & rain, moisture & dust could come in through the crack & either short out or disable…
ODI 10312927
Electrical System · Service Brakes, Hydraulic · Structure · Vehicle Speed Control
Ford fusion 2010 s - when the brake was depressed the car accelerated until i depressed a second time much harder. The consumer first began to notice the vehicle would intermittently not start in august. He took the vehicle to the dealer, but they were unable to duplicate the problem. The consumer insisted there was a problem and eventually, they found a technical service bulletin that addressed the issue. The…
ODI 10317487